Experimental evaluation of the usability of palm tree pruning waste (PTPW) as an alternative to geotextile

Authors

  • Ebubekir Kaplan Osmaniye Korkut Ata University, Faculty of Engineering, Department of Civil Engineering, Osmaniye (Turkey)
  • Cafer Kayadelen Osmaniye Korkut Ata University, Faculty of Engineering, Department of Civil Engineering, Osmaniye (Turkey)
  • Mitat Öztürk Osmaniye Korkut Ata University, Faculty of Engineering, Department of Civil Engineering, Osmaniye (Turkey)
  • Yakup Önal Osmaniye Korkut Ata University, Faculty of Engineering, Department of Civil Engineering, Osmaniye (Turkey)
  • Gökhan Altay Osmaniye Korkut Ata University, Faculty of Engineering, Department of Civil Engineering, Osmaniye (Turkey)

DOI:

https://doi.org/10.7764/RDLC.21.1.69

Keywords:

geotextile, soil stabilization, palm tree pruning waste, resilient modulus, Recycling waste materials

Abstract

This paper focuses on serving twofold benefits for the environment by providing not only recycling of a waste material but also improving rutting performance of sand subgrade under cyclic traffic loads. In this context, a series of laboratory experiments have been conducted to benchmark the performance of commercially manufactured geotextile and palm tree pruning waste (PTPW) as soil improvement agents. Experimental results of the study were evaluated based on permanent (plastic), total, and elastic deformation, rut depth reduction (RDR), traffic benefit ratio (TBR), percentage of elastic deformation, and resilient modulus (MR). In the view of experimental results, geotextile and PTPW-reinforced sand subgrades demonstrated well performance in the sense of permanent and elastic deformations when compared to unreinforced case. It is also realized that the most satisfactory performance was obtained when geotextile or PTPW are located at a burial depth of both 50 mm and 100 mm. In that case, TBR values of geotextile and PTPW-reinforced subgrades were almost the same at 20 mm permanent deformation (i.e., 6.71 and 6.76, respectively). Furthermore, when the results were evaluated based on RDR, it is observed that geotextile and PTPW reinforcements reduced the rut depth at the rate of 49.31 % and 37.15 % at the end of 5000 load cycle, respectively.

References

Abdeldjouad, L., Asadi, A., Ball, R. J., Nahazanan, H., & Huat, B. B. K. (2019). Application of alkali-activated palm oil fuel ash reinforced with glass fibers in soil stabilization. Soils and Foundations, 59(5), 1552–1561.

Ahlvin, R. G., & Ulery, H. H. (1962). Tabulated values for determining the complete pattern of stresses, strains, and deflections beneath a uniform circular load on a homogeneous half space. Highway Research Board Bulletin, (342).

Altay, G., Kayadelen, C., Canakci, H., Bagriacik, B., Ok, B., & Oguzhanoglu, M. A. (2021). Experimental investigation of deformation behavior of geocell retaining walls. Geomechanics and Engineering, Vol. 27, No. 5, 419-431

Altay, G., Kayadelen, C., Taskiran, T., Bagriacik, B., & Toprak, O. (2021). Frictional properties between geocells filled with granular material. Revista de la construcción, 20(2), 332-345.

Altay, G., Kayadelen, C., Taşkıran, T., & Kaya, Y. Z. (2019). A laboratory study on pull-out resistance of geogrid in clay soil. Measurement, 139, 301-307.

Arifin, Y. F., & Rahman, G. (2019). Stabilization of Soft Soil with Cement and Palm Kernel Shell Ash Admixture. MATEC Web of Conferences, 280, 04011.

Basha, E. A., Hashim, R., Mahmud, H. B., & Muntohar, A. S. (2005). Stabilization of residual soil with rice husk ash and cement. Construction and Building Materials, 19(6), 448–453.

Bhattacharyya, R., Fullen, M. A., Davies, K., & Booth, C. A. (2009). Utilizing palm-leaf geotextile mats to conserve loamy sand soil in the United Kingdom. Agriculture, Ecosystems and Environment, 130(1–2), 50–58.

Cuelho, E. V., & Perkins, S. W. (2017). Geosynthetic subgrade stabilization – Field testing and design method calibration. Transportation Geotechnics, 10, 22–34.

Evangeline, S. Y., Sayida, M. K., & Girish, M. S. (2019). Long-Term Performance of Rural Roads Reinforced with Coir Geotextile – A Field Study. Journal of Natural Fibers, 1–18.

Fannin, R. J., & Sigurdsson, O. (1996). Field Observations on Stabilization of Unpaved Roads with Geosynthetics. Journal of Geotechnical Engineering, 122(7), 544–553.

Ferrández-García, C.-E., Ferrández-García, A., Ferrández-Villena, M., Hidalgo-Cordero, J., García-Ortuño, T., & Ferrández-García, M.-T. (2018). Physical and Mechanical Properties of Particleboard Made from Palm Tree Prunings. Forests, 9(12), 755.

Garcia-Ortuno, T., Ferrandez Garcia, M. T., Andreu Rodriguez, J., Ferrandez Garcia, C. E., & Ferrandez-Villena, M. (2011). Evaluating the properties of palm particle boards (Washingtonia robusta H. Wendl). In Proceedings of the 6th Iberian Congress of Agroengineering, 126–130.

George, A. M., Banerjee, A., Puppala, A. J., & Saladhi, M. (2021). Performance evaluation of geocell-reinforced reclaimed asphalt pavement (RAP) bases in flexible pavements. International Journal of Pavement Engineering, 22(2), 181–191.

Gil-Lopez, T., Medina-Molina, M., Verdu-Vazquez, A., & Martel-Rodriguez, B. (2017). Acoustic and economic analysis of the use of palm tree pruning waste in noise barriers to mitigate the environmental impact of motorways. Science of the Total Environment, 584–585, 1066–1076.

Giroud, J. P., & Han, J. (2004). Design Method for Geogrid-Reinforced Unpaved Roads. I. Development of Design Method. Journal of Geotechnical and Geoenvironmental Engineering, 130(8), 775–786.

Gray, D. H., & Ohashi, H. (1983). Mechanics of Fiber Reinforcement in Sand. Journal of Geotechnical Engineering, 109(3), 335–353.

Hausmann, M. R. (1987). Geotextiles for unpaved roads-A review of design procedures. Geotextiles and Geomembranes, 5(3), 201–233.

Kayadelen, C., Önal, T. Ö., & Altay, G. (2018). Experimental study on pull-out response of geogrid embedded in sand. Measurement, 117, 390-396.

Mamatha, K. H., & Dinesh, S. V. (2019). Performance evaluation of geocell-reinforced pavements. International Journal of Geotechnical Engineering, 13(3), 277–286.

Mandal, I., & Pal, S. (2020). COVID-19 pandemic persuaded lockdown effects on environment over stone quarrying and crushing areas. Science of the Total Environment, 732, 139281.

Marandi, S. M., Bagheripour, M. H., Rahgozar, R., & Zare, H. (2008). Strength and ductility of randomly distributed palm fibers reinforced silty-sand soils. American Journal of Applied Sciences, 5(3), 209–220.

Mujah, D., Rahman, M. E., & Zain, N. H. M. (2015). Performance evaluation of the soft soil reinforced ground palm oil fuel ash layer composite. Journal of Cleaner Production, 95, 89–100.

Nair, A. M., & Latha, G. M. (2016). Repeated load tests on geosynthetic reinforced unpaved road sections. Geomechanics and Geoengineering, 11(2), 95–103.

Negi, M. S., & Singh, S. K. (2019). Experimental and numerical studies on geotextile reinforced subgrade soil. International Journal of Geotechnical Engineering, 1–12.

Nnochiri, E. S., Ogundipe, O. M., & Oluwatuyi, O. E. (2017). Effects of Palm Kernel Shell Ash on Lime-Stabilized Lateritic Soil. Slovak Journal of Civil Engineering, 25(3), 1–7.

Önal, Y. (2021). Geosentetiklerle güçlendirilmiş karayolu temel tabakasının davranışının tekrarlı yükler altında incelenmesi. Thesis (MSc). Osmaniye Korkut Ata University, Osmaniye, Turkey.

Palmeira, E. M., & Antunes, L. G. S. (2010). Large scale tests on geosynthetic reinforced unpaved roads subjected to surface maintenance. Geotextiles and Geomembranes, 28(6), 547–558.

Pokharel, S. K., Han, J., Leshchinsky, D., & Parsons, R. L. (2018). Experimental evaluation of geocell-reinforced bases under repeated loading. International Journal of Pavement Research and Technology, 11(2), 114–127.

Pokharel, S. K., Han, J., Leshchinsky, D., Parsons, R. L., & Halahmi, I. (2010). Investigation of factors influencing behavior of single geocell-reinforced bases under static loading. Geotextiles and Geomembranes, 28(6), 570–578.

Pourakbar, S., Asadi, A., Huat, B. B. K., & Fasihnikoutalab, M. H. (2015). Stabilization of clayey soil using ultrafine palm oil fuel ash (POFA) and cement. Transportation Geotechnics, 3, 24–35.

Qian, Y., Han, J., Pokharel, S. K., & Parsons, R. L. (2011). Determination of Resilient Modulus of Subgrade Using Cyclic Plate Loading Tests. 4743–4751.

Qu, J., & Xiong, K. (2020). Influences of Curing Environment on Strength Performances of Shanghai Clayey Soil Reinforced with Palm Fiber. Advances in Civil Engineering.

Qu, J., & Zhao, D. (2016). Stabilising the cohesive soil with palm fibre sheath strip. Road Materials and Pavement Design, 17(1), 87–103.

Qu, J., & Zhu, H. (2021). Function of palm fiber in stabilization of alluvial clayey soil in Yangtze River Estuary. Journal of Renewable Materials, 9(4), 767–787.

Rashidian, V., Naeini, S. A., & Mirzakhanlari, M. (2018). Laboratory testing and numerical modelling on bearing capacity of geotextile-reinforced granular soils. International Journal of Geotechnical Engineering, 12(3), 241–251.

Saride, S., Rayabharapu, V. K., & Vedpathak, S. (2015). Evaluation of Rutting Behaviour of Geocell Reinforced Sand Subgrades Under Repeated Loading. Indian Geotechnical Journal, 45(4), 378–388.

Shukla, S. K. (2002). Geosynthetics and their Applications. In Geosynthetics and their Applications.

Singh, M., Trivedi, A., & Shukla, S. K. (2019). Strength enhancement of the subgrade soil of unpaved road with geosynthetic reinforcement layers. Transportation Geotechnics, 19, 54–60.

Suku, L., Prabhu, S. S., Ramesh, P., & Babu, G. L. S. (2016). Behavior of geocell-reinforced granular base under repeated loading. Transportation Geotechnics, 9, 17–30.

Suku, L., Prabhu, S. S., & Sivakumar Babu, G. L. (2017). Effect of geogrid-reinforcement in granular bases under repeated loading. Geotextiles and Geomembranes, 45(4), 377–389.

Tafreshi, S. N. M., Khalaj, O., & Dawson, A. R. (2014). Repeated loading of soil containing granulated rubber and multiple geocell layers. Geotextiles and Geomembranes, 42(1), 25–38.

Thakur, J. K., Han, J., Pokharel, S. K., & Parsons, R. L. (2012). Performance of geocell-reinforced recycled asphalt pavement (RAP) bases over weak subgrade under cyclic plate loading. Geotextiles and Geomembranes, 35, 14–24.

Zhang, L., Zhao, M., Shi, C., & Zhao, H. (2010). Bearing capacity of geocell reinforcement in embankment engineering. Geotextiles and Geomembranes, 28(5), 475–482.

Downloads

Published

2022-04-18 — Updated on 2022-04-26

Versions

How to Cite

Kaplan, E. ., Kayadelen, C., Öztürk, M. ., Önal, Y., & Altay, G. (2022). Experimental evaluation of the usability of palm tree pruning waste (PTPW) as an alternative to geotextile. Revista De La Construcción. Journal of Construction, 21(1), 69–82. https://doi.org/10.7764/RDLC.21.1.69 (Original work published April 18, 2022)